CRM Mitchell1, Author at Truck Techs

2017 Chevrolet Silverado 2500 HD
Mileage
111,618
Service Date
8/21/2023
Services Performed
Verified glow plug codes. p0672 – cyl 2 glow plug control circuit p0674 – cyl 4 glow plug control circuit. Recommend replacing the bank of glow plugs.
verified humming noise coming from dash area. removed some of the panels and found that the noise is coming from the ac box. did find signs of someone being behind the dash. suspect maybe somthing was left loose. Unable to inspect. Need to remove dash and make sure everything is tight.
Verified glow plug codes. p0672 – cyl 2 glow plug control circuit p0674 – cyl 4 glow plug control circuit. Recommend replacing the bank of glow plugs. Bank of glow plugs removed and replaced. Cleared codes and tested. VErified no check engine at this time. Vehicle may not be turning on the glow plugs due to ambient temp being 100 plus. did 3 key cycles and no check engine light after key cycles.
Benny B. gave our service a 5 star review on 8/23/2023
2018 Ford F-250 Super Duty
Mileage
132,501
Service Date
8/16/2023
Services Performed
vehicle has code for p2074 – map/maf correlation at full throttle. inspected the air filter and found dirty, also found debris on top of the air filter. Inspected sensor and found maf sensor dirty. Recommend replacing sensors and filter, then retesting. Air filter removed and replaced. Cleaned the maf sensor and replaced. Cleared all parameters and test drove. No codes at this time.
MASS AIR FLOW SENSOR – Remove & Replace – [Includes: Component test.] and MAP SENSOR
Removed the high pressure pump and replaced with aftermarket s&s pump. Torrqued the pump gear to spec. Torqued the high pressure pump and all associated fuel lines to spec. Primed the fuel system and started the vehicle. Truck runs as intended and verified no leaks after replacing.
Slade S. gave our service a 5 star review on 8/17/2023
2018 RAM 2500 HD
Mileage
110,915
Service Date
8/1/2023
Services Performed
Test drove Vehicle brakes worked fine, did feel slight wheel vibration. Raised vehicle on lift inspected suspension and brakes, brakes all around look good. Notice front tires thread are cupped, suspension also cant find any obvious faults. Tested ball joints, tie rods, and u-joints did feel slight play on drag link. Recommend replacing tires.
Test drove vehicle and scanned for codes. none present was unable to duplicate concern.
Changed oil and filter
Check all fluids
Recommend crankcase vent filter, air filter, fuel filters still at 53%. do to maintenance schedule power steering flush is due, front and rear axle service.
Removed and Cleaned egr system.
Removed and replaced air filter
Removed and replaced cabin filter
Removed and replaced crankcase vent filter
Performed front diff service
Performed rear diff service
Performed transfer case service
Removed and replaced transmission filters and filled to specified level.
Performed coolant system service Drove vehicle and let it idle over an hour set fluid to proper level.
Removed and replaced thermostat and gasket
Performed brake system service
Removed and replaced serpent belt and tensioner.
Eric S. gave our service a 5 star review on 8/2/2023
2012 Ford Pickup
Mileage
163,283
Service Date
7/14/2023
Services Performed
CS she wants an oil change
Change oil and filter
Khris S. gave our service a 5 star review on 7/20/2023
2014 Ford F-250 Super Duty
Mileage
195,903
Service Date
7/10/2023
Services Performed
Verified concern. Performed PCM self test – P02DA Cylinder 8 Fuel Injector A Offset. Monitored all 8 cylinders mass balance PID – readings all over the place. Checked power balance – all 8 cylinders contributing evenly. Collected fuel sample and inspected fuel filter – OK. Verified injector values on bank 2 matched values in PCM. Performed relative compression test – found cylinder 3 dropping out 19%. Road tested – cylinder 3 dropping out in power balance and noticed excessive white smoke coming out the tailpipe. Recommend replacement of short block assembly.
Alejandro V. gave our service a 5 star review on 7/11/2023
2017 Ford F-150
Mileage
66,980
Service Date
6/13/2023
Services Performed
installed brake controller and verified proper operation.
Fuel
drained tank and filled with fresh fuel. Misfire seemed to go away, but on start up vehicle was still smoking.. Exhaust smells like coolant. After driving the smoke eventually cleared up. Vehicle still misfiring when sitting at a stop. vehicle also had a code p0137 – o2 sensor circuit low voltage bank 1 sensor 2. Cleared KAM and misfire parameters. Test drove. No codes at this time. Vehicle still feels like it has a intermittent slight misfire but no codes. Vehicle still learning and may need to be driven further.
COOLING SYSTEM – Diagnosis – [Includes: Pressure test for leaks, inspect Belts and Hoses and test Radiator Cap.]
Turbo loosened and separated from the cylinder head. Coolant system pressurized. Found coolant immediatly leaking from the cylinder head. Suspect a crack in the head. Recommend replacing the cylinder head.
SPark plugs removed and inspected the cylinder with a borescope. found cylinder 3 wet. Put a coolant pressure test on the system and inspected. Cylinder three did not change or fill with coolant. Recommend removing the turbo and inspecting the turbo inlet and cylinder head exhaust.
Alan C. gave our service a 5 star review on 6/27/2023
2015 Ford F-350 Super Duty
Mileage
97,048
Service Date
5/22/2023
Services Performed
Collected Sample from Fuel Water separator to inspect, orange brownish color water came out with diesel.
Changed oil and filter
Rudy G. gave our service a 5 star review on 6/2/2023
2018 Chevrolet Silverado 2500 HD
Mileage
200,009
Service Date
5/4/2023
Services Performed
found reductant level sensor failed need to replace and reset system to test nox sensor
removed and replaced the reductant pump assembly. Cleared all reductant tables, nox 1 sensor tables. Performed reductant test and test passed. Test drove and verified no codes after test drive.
Vehicle completed manual regen. No codes after.
Jose C. gave our service a 5 star review on 5/10/2023
2018 Ford F-250 Super Duty
Mileage
91,728
Service Date
4/28/2023
Services Performed
Changed oil and filter. Checked everything all checked out good. Checked front brake and rear brakes and greased all joints.
AIR CLEANER ELEMENT – Remove & Replace
Michael M. gave our service a 5 star review on 4/29/2023
2005 Chevrolet Silverado
Mileage
226,106
Service Date
3/13/2023
Services Performed
vehicle has p0201 – cylinder 1 injector circuit problem p0204 – cylinder 4 injector circuit problem p0206 – cylinder 6 injector circuit problem p0207 – cylinder 7 injector circuit problem p0670 – glow plug module control circuit p2146 – injection position voltage control circuit group 1 inspected wiring harness and unable to find any obvious signs of damage. Wiggled pigtails and 2 of the connectors felt a little sloppy at the injectors. Recommend replacing the rest of the injector connectors associated with the codes and retesting.
Replace number 1 injector pigtail
Replace 4 and 6 injector connectors
Steve H. gave our service a 5 star review on 3/15/2023

CRM Mitchell1

We Service and Repair all CRM Mitchell1 cars