2012 Ford Pickup
Mileage
74,376
Service Date
9/25/2025
Services Performed
- Starter seems to be getting stuck, recommend replacing and retesting.
- Inspected hub actuators: they were on locked mode set to auto. Passenger side was making noise while spinning wheel, removed actuator and noise went away. Tried to replicate noise again and have not been able to at this time. Found front u-joints have excessive play.
- Noise seems to be coming from top fuel filter.
- CS check engine light comes on with code P062A, only when it's raining and gets wet.
- Inspected fuel pump (aftermarket) = noticed filters appear to have not been replaced in a while. Recommend replacing filters. Fuel level also low, might be causing louder fuel pump noise.
- Removed and replaced starter.
- Removed and replaced fuel filters
- Visually inspected for oil leak = found engine valley with oil, bottom of engine all covered in oil also. Found dried oil seepage from front cover down to oil pan. Cleaned up some of oil from valley and under engine. Test drove vehicle = oil leak coming from top engine down to passenger side covering starter. Recommend turbo reseal and power washing engine to reinspect.
- Removed and re-installed axle shafts to replace u-joints
- Removed and replaced u-joints
- Removed and resealed then re-installed turbocharger
- Removed and replaced oil separator
- Removed and replaced drag link
- Removed and replaced tie rod ends
- Removed and replaced tie rod
- Alignment
- Removed and replaced thermostat
- Power washed engine
Trevor W. gave our service a 5 star review on 9/25/2025
